2019-26850. Airworthiness Directives; Gulfstream Aerospace Corporation Airplanes  

  • Start Preamble

    AGENCY:

    Federal Aviation Administration (FAA), DOT.

    ACTION:

    Notice of proposed rulemaking (NPRM).

    SUMMARY:

    The FAA proposes to adopt a new airworthiness directive (AD) for certain Gulfstream Aerospace Corporation (Gulfstream) Model GVI airplanes. This proposed AD was prompted by a report that the primary flight control actuation system (PFCAS) linear variable displacement transducer (LVDT) mechanical disconnect monitor may not trigger the disconnect of the affected control surfaces as required in the event of a control surface failure. This proposed AD would require updating the software of each PFCAS remote electronics unit (REU), which includes an improvement to the LVDT. The FAA is proposing this AD to address the unsafe condition on these products.

    DATES:

    The FAA must receive comments on this proposed AD by January 30, 2020.

    ADDRESSES:

    You may send comments, using the procedures found in 14 CFR 11.43 and 11.45, by any of the following methods:

    • Federal eRulemaking Portal: Go to https://www.regulations.gov. Follow the instructions for submitting comments.
    • Fax: 202-493-2251.
    • Mail: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE, Washington, DC 20590.
    • Hand Delivery: Deliver to Mail address above between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.

    For service information identified in this NPRM, contact Gulfstream Aerospace Corporation, Technical Publications Dept., P.O Box 2206, Savannah, GA 31402-2206; telephone: (800) 810-4853; fax: (912) 965-3520; email: pubs@gulfstream.com; internet: https://www.gulfstream.com/​customer-support. You may view this service information at the FAA, Policy and Innovation Division, 901 Locust, Kansas City, Missouri 64106. For information on the availability of this material at the FAA, call (816) 329-4148.

    Examining the AD Docket

    You may examine the AD docket on the internet at https://www.regulations.gov by searching for and locating Docket No. FAA-2019-1024; or in person at Docket Operations between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this proposed AD, the regulatory evaluation, any comments received, and other information. The street address for Docket Operations is listed above. Comments will be available in the AD docket shortly after receipt.

    Start Further Info

    FOR FURTHER INFORMATION CONTACT:

    Myles Jalalian, Aerospace Engineer, Atlanta ACO Branch, FAA, 1701 Columbia Avenue, College Park, Georgia 30337; phone: (404) 474-5572; fax: (404) 474-5606; email: myles.jalalian@faa.gov.

    End Further Info End Preamble Start Supplemental Information

    SUPPLEMENTARY INFORMATION:

    Comments Invited

    The FAA invites you to send any written relevant data, views, or arguments about this proposal. Send your comments to an address listed under the ADDRESSES section. Include “Docket No. FAA-2019-1024; Product Identifier 2019-CE-002-AD” at the beginning of your comments. The FAA specifically invites comments on the overall regulatory, economic, environmental, and energy aspects of this NPRM. The FAA will consider all comments received by the closing date and may amend this NPRM because of those comments.

    The FAA will post all comments received, without change, to https://www.regulations.gov,, including any personal information you provide. The FAA will also post a report summarizing each substantive verbal contact received about this NPRM.

    Discussion

    The FAA received a report from Gulfstream that the PFCAS LVDT mechanical disconnect monitor may not trigger the disconnect of the affected control surfaces as required in the event of a control surface failure. The Model GVI flight control computer actuator LVDT disconnect monitor should disable the control surface for ailerons, elevators, and rudder in the event that one of those control surfaces fails. Gulfstream developed an REU software update that provides improvements to the LVDT of the PFCAS, which addresses the LVDT disconnect monitor problem. This condition, if not addressed, could lead to spoiler hard-over or loss of structural integrity due to excessive surface deflection and result in loss of control of the airplane.

    Related Service Information Under 1 CFR Part 51

    The FAA reviewed Gulfstream G650 Customer Bulletin Number 201, dated September 28, 2017, and Gulfstream G650ER Customer Bulletin Number 201, dated September 28, 2017; which specify incorporating Gulfstream G650 Aircraft Service Change 069, dated September 28, 2017, or Gulfstream G650ER Aircraft Service Change 069, dated September 28, 2017. This service information differs because each document applies to a different airplane designation.

    The FAA also reviewed Gulfstream G650 Aircraft Service Change 069, dated Start Printed Page 68364September 28, 2017, and Gulfstream G650ER Aircraft Service Change 069, dated September 28, 2017, which provide and reference procedures for preparing the REU for a software update.

    The FAA reviewed Parker Service Bulletin 469000-27-003, Revision 1, dated October 11, 2017, which contains procedures for updating the software of the REU from Label 34 to Label 35. This update includes improved LVDT disconnect and oscillatory monitoring, force fight mitigation, troubleshooting, and rectification of other reported problems.

    This service information is reasonably available because the interested parties have access to it through their normal course of business or by the means identified in the ADDRESSES section.

    FAA's Determination

    The FAA is proposing this AD because it evaluated all the relevant information and determined the unsafe condition described previously is likely to exist or develop in other products of the same type design.

    Proposed D Requirements

    This proposed AD would require accomplishing the actions specified in the service information described previously.

    Costs of Compliance

    The FAA estimates that this proposed AD would affect 161 airplanes of U.S. registry.

    The FAA estimates the following costs to comply with this proposed AD:

    Estimated Costs

    ActionLabor costParts costCost per productCost on U.S. operators
    Update REU software386 work-hours × $85 per hour = $32,810None$32,810$5,282,410

    According to the manufacturer, some of the costs of this proposed AD may be covered under warranty, thereby reducing the cost impact on affected individuals. The FAA does not control warranty coverage for affected individuals. As a result, the FAA has included all costs in this cost estimate.

    Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs, describes in more detail the scope of the Agency's authority.

    The FAA is issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, section 44701: General requirements. Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

    This proposed AD is issued in accordance with authority delegated by the Executive Director, Aircraft Certification Service, as authorized by FAA Order 8000.51C. In accordance with that order, issuance of ADs is normally a function of the Compliance and Airworthiness Division, but during this transition period, the Executive Director has delegated the authority to issue ADs applicable to small airplanes, gliders, balloons, airships, domestic business jet transport airplanes, and associated appliances to the Director of the Policy and Innovation Division.

    Regulatory Findings

    The FAA determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.

    For the reasons discussed above, I certify this proposed regulation:

    (1) Is not a “significant regulatory action” under Executive Order 12866,

    (2) Will not affect intrastate aviation in Alaska, and

    (3) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

    Start List of Subjects

    List of Subjects in 14 CFR Part 39

    • Air transportation
    • Aircraft
    • Aviation safety
    • Incorporation by reference
    • Safety
    End List of Subjects

    The Proposed Amendment

    Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:

    Start Part

    PART 39—AIRWORTHINESS DIRECTIVES

    End Part Start Amendment Part

    1. The authority citation for part 39 continues to read as follows:

    End Amendment Part Start Authority

    Authority: 49 U.S.C. 106(g), 40113, 44701.

    End Authority
    [Amended]
    Start Amendment Part

    2. The FAA amends § 39.13 by adding the following new airworthiness directive (AD):

    End Amendment Part

    Gulfstream Aerospace Corporation: Docket No. FAA-2019-1024; Product Identifier 2019-CE-002-AD.

    (a) Comments Due Date

    The FAA must receive comments by January 30, 2020.

    (b) Affected ADs

    None.

    (c) Applicability

    This AD applies to Gulfstream Aerospace Corporation Model GVI airplanes, certificated in any category, serial numbers 6001 through 6111, 6113 through 6133, and 6135 through 6274.

    Note 1 to paragraph (c) of this AD: Model GVI airplanes are also referred to by the marketing designations G650 and G650ER.

    (d) Subject

    Joint Aircraft System Component (JASC)/Air Transport Association (ATA) of America Code 27, Flight Controls.

    (e) Unsafe Condition

    This AD was prompted by a report that the primary flight control actuation system (PFCAS) linear variable displacement transducer (LVDT) mechanical disconnect monitor may not trigger the disconnect of the affected control surfaces as required in the event of a control surface failure. This condition, if not addressed, could lead to spoiler hard-over or loss of structural integrity due to excessive surface deflection and result in loss of control of the airplane.

    (f) Compliance

    Comply with this AD within the compliance times specified, unless already done.Start Printed Page 68365

    (g) Software Upgrade

    Within the next 24 months after the effective date of this AD, update the software for each PFCAS remote electronics unit (REU) from Label 34 to Label 35 by following the Accomplishment Instructions in Gulfstream G650 Customer Bulletin Number 201, dated September 28, 2017, or Gulfstream G650ER Customer Bulletin Number 201, dated September 28, 2017; the Modification Instructions, sections A through C, in Gulfstream G650 Aircraft Service Change No. 069, dated September 28, 2017, or Gulfstream G650ER Aircraft Service Change No. 069, dated September 28, 2017; and the Accomplishment Instructions in Parker Service Bulletin 469000-27-003, Revision 1, dated October 11, 2017; except you are not required to submit information to the manufacturer.

    (h) Alternative Methods of Compliance (AMOCs)

    (1) The Manager, Atlanta ACO Branch, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the manager of the certification office, send it to the attention of the person identified in paragraph (i)(1) of this AD.

    (2) Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/certificate holding district office.

    (3) For service information that contains steps that are labeled as Required for Compliance (RC), the provisions of paragraphs (h)(3)(i) and (ii) of this AD apply.

    (i) The steps labeled as RC, including substeps under an RC step and any figures identified in an RC step, must be done to comply with the AD. An AMOC is required for any deviations to RC steps, including substeps and identified figures.

    (ii) Steps not labeled as RC may be deviated from using accepted methods in accordance with the operator's maintenance or inspection program without obtaining approval of an AMOC, provided the RC steps, including substeps and identified figures, can still be done as specified, and the airplane can be put back in an airworthy condition.

    (i) Related Information

    (1) For more information about this AD, contact Myles Jalalian, Aerospace Engineer, Atlanta ACO Branch, FAA, 1701 Columbia Avenue, College Park, Georgia 30337; phone: (404) 474-5572; fax: (404) 474-5606; email: myles.jalalian@faa.gov.

    (2) For service information identified in this AD, contact Gulfstream Aerospace Corporation, Technical Publications Dept., P.O. Box 2206, Savannah, GA 31402-2206; telephone: (800) 810-4853; fax: (912) 965-3520; email: pubs@gulfstream.com; internet: https://www.gulfstream.com/​customer-support. You may obtain Parker-Hannifin service information using the contact information for Gulfstream Aerospace Corporation. You may view this referenced service information at the FAA, Policy and Innovation Division, 901 Locust, Kansas City, Missouri 64106. For information on the availability of this material at the FAA, call (816) 329-4148.

    Start Signature

    Issued on December 2, 2019.

    Patrick R. Mullen,

    Aircraft Certification Service, Manager, Small Airplane Standards Branch, AIR-690.

    End Signature End Supplemental Information

    [FR Doc. 2019-26850 Filed 12-13-19; 8:45 am]

    BILLING CODE 4910-13-P

Document Information

Published:
12/16/2019
Department:
Federal Aviation Administration
Entry Type:
Proposed Rule
Action:
Notice of proposed rulemaking (NPRM).
Document Number:
2019-26850
Dates:
The FAA must receive comments on this proposed AD by January 30, 2020.
Pages:
68363-68365 (3 pages)
Docket Numbers:
Docket No. FAA-2019-1024, Product Identifier 2019-CE-002-AD
RINs:
2120-AA64: Airworthiness Directives
RIN Links:
https://www.federalregister.gov/regulations/2120-AA64/airworthiness-directives
Topics:
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety
PDF File:
2019-26850.Pdf
Supporting Documents:
» 2019-CE-002 No Comments Received Form
» Supporting AD Documents
» Supporting AD Documents
CFR: (1)
14 CFR 39.13