05-3286. Airworthiness Directives; Dornier Model 328-300 Series Airplanes

AGENCY:

Federal Aviation Administration (FAA), Department of Transportation (DOT).

ACTION:

Notice of proposed rulemaking (NPRM).

SUMMARY:

The FAA proposes to adopt a new airworthiness directive (AD) for all Dornier Model 328-300 series airplanes. This proposed AD would require installing an additional mounting angle for the respective de-icing pipes at rib 9 in the leading edge area of the left- and right-hand wings. This proposed AD is prompted by chafed de-icing lines in the wing leading edge area. We are proposing this AD to prevent chafing of the de-icing lines, which could result in a reduction in functionality of the anti-ice system, and possibly reduced controllability and performance of the airplane in icing conditions.

DATES:

We must receive comments on this proposed AD by March 24, 2005.

ADDRESSES:

Use one of the following addresses to submit comments on this proposed AD.

• DOT Docket Web Site: Go to http://dms.dot.gov and follow the instructions for sending your comments electronically.
• Government-wide Rulemaking Web Site: Go to http://www.regulations.gov and follow the instructions for sending your comments electronically.
• Mail: Docket Management Facility, U.S. Department of Transportation, 400 Seventh Street SW., Nassif Building, room PL-401, Washington, DC 20590.
• By Fax: [phone].
• Hand Delivery: Room PL-401 on the plaza level of the Nassif Building, 400 Seventh Street SW., Washington, DC, between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.

For service information identified in this proposed AD, contact AvCraft Aerospace GmbH, P.O. Box 1103, D-82230 Wessling, Germany.

You can examine the contents of this AD docket on the Internet at http://dms.dot.gov,, or in person at the Docket Management Facility, U.S. Department of Transportation, 400 Seventh Street SW., room PL-401, on the plaza level of the Nassif Building, Washington, DC. This docket number is FAA-2005-20414; the directorate identifier for this docket is 2004-NM-116-AD.

FOR FURTHER INFORMATION CONTACT:

Dan Rodina, Aerospace Engineer, International Branch, ANM-116, FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington 98055-4056; telephone [phone]; fax [phone].

SUPPLEMENTARY INFORMATION:

Comments Invited

We invite you to submit any relevant written data, views, or arguments regarding this proposed AD. Send your comments to an address listed under ADDRESSES. Include “Docket No. FAA-2005-20414; Directorate Identifier 2004-NM-116-AD” at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of the proposed AD. We will consider all comments submitted by the closing date and may amend the proposed AD in light of those comments.

We will post all comments we receive, without change, to http://dms.dot.gov,, including any personal information you provide. We will also post a report summarizing each substantive verbal contact with FAA personnel concerning this proposed AD. Using the search function of our docket Web site, anyone can find and read the comments in any of our dockets, including the name of the individual who sent the comment (or signed the comment on behalf of an association, business, labor union, etc.). You can review the DOT's complete Privacy Act Statement in the Federal Register published on April 11, 2000 (65 FR 19477-78), or you can visit http://dms.dot.gov.

Examining the Docket

You can examine the AD docket on the Internet at http://dms.dot.gov,, or in person at the Docket Management Facility office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The Docket Management Facility office (telephone [phone]) is located on the plaza level of the Nassif Building at the DOT street address stated in the ADDRESSES section. Comments will be available in the AD docket shortly after the DMS receives them.

Discussion

The Luftfahrt-Bundesamt (LBA), which is the airworthiness authority for Germany, notified us that an unsafe condition may exist on all Dornier Model 328-300 series airplanes. The LBA advises that, during inspections, de-icing lines were found chafed in the leading edge area of the left- and right-hand wings. The chafing was caused by insufficient clearance from the de-icing lines to the adjacent airplane structure. This condition, if not corrected, could result in a reduction in functionality of the anti-ice system, and possibly reduced controllability and performance of the airplane in icing conditions.

Relevant Service Information

Dornier has issued Service Bulletin SB-328J-30-190, dated July 16, 2003. The service bulletin describes procedures for installing an additional mounting angle for the respective de-icing pipes at rib 9 in the leading edge area of the left- and right-hand wings. Accomplishing the actions specified in the service information is intended to adequately address the unsafe condition. The LBA mandated the service information and issued German airworthiness directive D-2004-049, dated February 1, 2004, to ensure the continued airworthiness of these airplanes in Germany.

FAA's Determination and Requirements of the Proposed AD

This airplane model is manufactured in Germany and is type certificated for operation in the United States under the provisions of section 21.29 of the Federal Aviation Regulations (14 CFR 21.29) and the applicable bilateral airworthiness agreement. Pursuant to this bilateral airworthiness agreement, the LBA has kept the FAA informed of the situation described above. We have examined the LBA's findings, evaluated all pertinent information, and determined that we need to issue an AD for products of this type design that are certificated for operation in the United States.

Therefore, we are proposing this AD, which would require accomplishing the actions specified in the service information described previously.

Costs of Compliance

The following table provides the estimated costs for U.S. operators to comply with this proposed AD.

Estimated Costs

Action	Work hours	Average labor rate per hour	Parts	Cost per airplane	Number of U.S.- registered airplanes	Fleet cost
Installation	8	$65	$252	$772	49	$37,828

Authority for This Rulemaking

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency's authority.

We are issuing this rulemaking under the authority described in subtitle VII, part A, subpart III, section 44701, “General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

Regulatory Findings

We have determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.

For the reasons discussed above, I certify that the proposed regulation:

1. Is not a “significant regulatory action” under Executive Order 12866;

2. Is not a “significant rule” under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and

3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

We prepared a regulatory evaluation of the estimated costs to comply with this proposed AD. See the ADDRESSES section for a location to examine the regulatory evaluation.

List of Subjects in 14 CFR Part 39

• Air transportation
• Aircraft
• Aviation safety
• Safety

The Proposed Amendment

Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:

PART 39—AIRWORTHINESS DIRECTIVES

1. The authority citation for part 39 continues to read as follows:

Authority: 49 U.S.C. 106(g), 40113, 44701.

§ 39.13

[Amended]

2. The FAA amends § 39.13 by adding the following new airworthiness directive (AD):

Fairchild Dornier GMBH (Formerly Dornier Luftfahrt GmbH): Docket No. FAA-2005-20414; Directorate Identifier 2004-NM-116-AD.

Comments Due Date

(a) The Federal Aviation Administration must receive comments on this AD action by March 24, 2005.

Affected ADs

(b) None.

Applicability

(c) This AD applies to all Dornier Model 328-300 series airplanes, certificated in any category.

Unsafe Condition

(d) This AD was prompted by chafed de-icing lines in the wing leading edge area. We are issuing this AD to prevent chafing of the de-icing lines, which could result in a reduction in functionality of the anti-ice system, and possibly reduced controllability and performance of the airplane in icing conditions.

Compliance

(e) You are responsible for having the actions required by this AD performed within the compliance times specified, unless the actions have already been done.

Installation

(f) Within 90 days after the effective date of this AD, install an additional mounting angle at rib 9 in the leading edge area of the left- and right-hand wings in accordance with the Accomplishment Instructions of Dornier Service Bulletin SB-328J-30-190, dated July 16, 2003.

Alternative Methods of Compliance (AMOCs)

(g) The Manager, International Branch, ANM-116, FAA, Transport Airplane Directorate, has the authority to approve AMOCs for this AD, if requested in accordance with the procedures found in 14 CFR 39.19.

Related Information

(h) German airworthiness directive D-2004-049, dated February 1, 2004, also addresses the subject of this AD.

Issued in Renton, Washington, on February 14, 2005.

Ali Bahrami,

Manager, Transport Airplane Directorate, Aircraft Certification Service.