2021-10068. Airworthiness Directives; BAE Systems (Operations) Limited Airplanes  

  • Start Preamble Start Printed Page 26149

    AGENCY:

    Federal Aviation Administration (FAA), Department of Transportation (DOT).

    ACTION:

    Final rule.

    SUMMARY:

    The FAA is adopting a new airworthiness directive (AD) for all BAE Systems (Operations) Limited Model BAe 146 and Model Avro 146-RJ series airplanes. This AD was prompted by a report indicating that during a routine battery capacity check on the emergency light power units, the printed circuit boards (PCBs) for certain power units were found to show signs of burning. This AD requires replacing each Honeywell emergency light power unit having a certain part number with a serviceable emergency light power unit. The FAA is issuing this AD to address the unsafe condition on these products.

    DATES:

    This AD is effective June 17, 2021.

    ADDRESSES:

    Examining the AD Docket

    You may examine the AD docket on the internet at https://www.regulations.gov by searching for and locating Docket No. FAA-2021-0138; or in person at Docket Operations between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this final rule, any comments received, and other information. The address for Docket Operations is U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE, Washington, DC 20590.

    Start Further Info

    FOR FURTHER INFORMATION CONTACT:

    Todd Thompson, Aerospace Engineer, Large Aircraft Section, International Validation Branch, FAA, 2200 South 216th St., Des Moines, WA 98198; telephone and fax: 206-231-3228; email: Todd.Thompson@faa.gov.

    End Further Info End Preamble Start Supplemental Information

    SUPPLEMENTARY INFORMATION:

    Background

    The European Union Aviation Safety Agency (EASA), which is the Technical Agent for the Member States of the European Union, has issued EASA AD 2020-0237, dated October 28, 2020 (EASA AD 2020-0237) (also referred to as the Mandatory Continuing Airworthiness Information, or the MCAI), to correct an unsafe condition for all BAE Systems (Operations) Limited Model BAe 146 and Model Avro 146-RJ series airplanes. You may examine the MCAI in the AD docket at https://www.regulations.gov by searching for and locating Docket No. FAA-2021-0138.

    The FAA issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 by adding an AD that would apply to all BAE Systems (Operations) Limited Model BAe 146 and Model Avro 146-RJ series airplanes. The NPRM published in the Federal Register on March 15, 2021 (86 FR 14283). The NPRM was prompted by a report indicating that during a routine battery capacity check on the emergency light power units, the PCBs for certain power units were found to show signs of burning. The NPRM proposed to require replacing each Honeywell emergency light power unit having a certain part number with a serviceable emergency light power unit. The FAA is issuing this AD to address heat damage of the PCBs, which could lead to battery discharge and possibly result in lack of power supply to the emergency light units when needed. See the MCAI for additional background information.

    Comments

    The FAA gave the public the opportunity to participate in developing this final rule. The FAA received no comments on the NPRM or on the determination of the cost to the public.

    Conclusion

    The FAA reviewed the relevant data and determined that air safety and the public interest require adopting this final rule as proposed, except for minor editorial changes. The FAA has determined that these minor changes:

    • Are consistent with the intent that was proposed in the NPRM for addressing the unsafe condition; and
    • Do not add any additional burden upon the public than was already proposed in the NPRM.

    Costs of Compliance

    The FAA estimates that this AD affects 30 airplanes of U.S. registry. The FAA estimates the following costs to comply with this AD:

    Estimated Costs for Required Actions

    Labor costParts costCost per productCost on U.S. operators
    2 work-hours × $85 per hour = $170$1,800$1,970$59,100

    Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs, describes in more detail the scope of the Agency's authority.

    The FAA is issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701: General requirements. Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and Start Printed Page 26150procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

    Regulatory Findings

    This AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.

    For the reasons discussed above, I certify that this AD:

    (1) Is not a “significant regulatory action” under Executive Order 12866,

    (2) Will not affect intrastate aviation in Alaska, and

    (3) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

    Start List of Subjects

    List of Subjects in 14 CFR Part 39

    • Air transportation
    • Aircraft
    • Aviation safety
    • Incorporation by reference
    • Safety
    End List of Subjects

    Adoption of the Amendment

    Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:

    Start Part

    PART 39—AIRWORTHINESS DIRECTIVES

    End Part Start Amendment Part

    1. The authority citation for part 39 continues to read as follows:

    End Amendment Part Start Authority

    Authority: 49 U.S.C. 106(g), 40113, 44701.

    End Authority
    [Amended]
    Start Amendment Part

    2. The FAA amends § 39.13 by adding the following new airworthiness directive:

    End Amendment Part

    2021-10-27 BAE Systems (Operations) Limited: Amendment 39-21560; Docket No. FAA-2021-0138; Project Identifier MCAI-2020-01466-T.

    (a) Effective Date

    This airworthiness directive (AD) is effective June 17, 2021.

    (b) Affected ADs

    None.

    (c) Applicability

    This AD applies to all BAE Systems (Operations) Limited airplanes specified in paragraphs (c)(1) and (2) of this AD, certificated in any category.

    (1) Model BAe 146-100A, -200A, and -300A airplanes.

    (2) Model Avro 146-RJ70A, 146-RJ85A, and 146-RJ100A airplanes.

    (d) Subject

    Air Transport Association (ATA) of America Code 33, Lights.

    (e) Unsafe Condition

    This AD was prompted by a report indicating that during a routine battery capacity check on the emergency light power units, the printed circuit boards (PCBs) for power units LE 10 and LE 22 (Illustrated Parts Catalog (IPC) 33-50-00) were found to show signs of burning. The FAA is issuing this AD to address heat damage of the PCBs, which could lead to battery discharge and possibly result in lack of power supply to the emergency light units when needed.

    (f) Compliance

    Comply with this AD within the compliance times specified, unless already done.

    (g) Definitions

    (1) An affected part is defined as a Honeywell emergency light power unit, having part number 60-3550-1, except for those modified and marked using the instructions specified in Honeywell Service Bulletin 60-3550-33-0001, Revision 1, dated September 3, 2013.

    (2) A serviceable part is defined as an emergency light power unit that is not an affected part.

    (3) Group 1 airplanes are those that have an affected part installed.

    (4) Group 2 airplanes are those that do not have an affected part installed.

    (h) Replacement

    Within two months after the effective date of this AD: Replace each affected part with a serviceable part.

    Note 1 to paragraph (h):

    BAE Systems (Operations) Limited Service Bulletin ISB.33-081, dated November 4, 2019, contains information related to the replacement specified in paragraph (h) of this AD.

    (i) Parts Installation Prohibition

    As of the applicable compliance times specified in paragraphs (i)(1) or (2) of this AD, do not install an affected part on any airplane.

    (1) For Group 1 airplanes: After replacement of each affected part on an airplane as specified in paragraph (h) of this AD.

    (2) For Group 2 airplanes: As of the effective date of this AD.

    (j) Other FAA AD Provisions

    The following provisions also apply to this AD:

    (1) Alternative Methods of Compliance (AMOCs): The Manager, Large Aircraft Section, International Validation Branch, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or responsible Flight Standards Office, as appropriate. If sending information directly to the Large Aircraft Section, International Validation Branch, send it to the attention of the person identified in paragraph (k)(2) of this AD. Information may be emailed to: 9-AVS-AIR-730-AMOC@faa.gov. Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the responsible Flight Standards Office.

    (2) Contacting the Manufacturer: For any requirement in this AD to obtain instructions from a manufacturer, the instructions must be accomplished using a method approved by the Manager, Large Aircraft Section, International Validation Branch, FAA; or the European Union Aviation Safety Agency (EASA); or BAE Systems (Operations) Limited's EASA Design Organization Approval (DOA). If approved by the DOA, the approval must include the DOA-authorized signature.

    (k) Related Information

    (1) Refer to Mandatory Continuing Airworthiness Information (MCAI) EASA AD 2020-0237, dated October 28, 2020, for related information. This MCAI may be found in the AD docket on the internet at https://www.regulations.gov by searching for and locating Docket No. FAA-2021-0138.

    (2) For more information about this AD, contact Todd Thompson, Aerospace Engineer, Large Aircraft Section, International Validation Branch, FAA, 2200 South 216th St., Des Moines, WA 98198; telephone and fax: 206-231-3228; email Todd.Thompson@faa.gov.

    (3) For service information identified in this AD that is not incorporated by reference, contact BAE Systems (Operations) Limited, Customer Information Department, Prestwick International Airport, Ayrshire, KA9 2RW, Scotland, United Kingdom; telephone +44 1292 675207; fax +44 1292 675704; email RApublications@baesystems.com; internet http://www.baesystems.com.

    (l) Material Incorporated by Reference

    None.

    Start Signature

    Issued on May 7, 2021.

    Gaetano A. Sciortino,

    Deputy Director for Strategic Initiatives, Compliance & Airworthiness Division, Aircraft Certification Service.

    End Signature End Supplemental Information

    [FR Doc. 2021-10068 Filed 5-12-21; 8:45 am]

    BILLING CODE 4910-13-P

Document Information

Effective Date:
6/17/2021
Published:
05/13/2021
Department:
Federal Aviation Administration
Entry Type:
Rule
Action:
Final rule.
Document Number:
2021-10068
Dates:
This AD is effective June 17, 2021.
Pages:
26149-26150 (2 pages)
Docket Numbers:
Docket No. FAA-2021-0138, Project Identifier MCAI-2020-01466-T, Amendment 39-21560, AD 2021-10-27
RINs:
2120-AA64: Airworthiness Directives
RIN Links:
https://www.federalregister.gov/regulations/2120-AA64/airworthiness-directives
Topics:
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety
PDF File:
2021-10068.pdf
Supporting Documents:
» U.S. DOT/FAA - Supporting AD Document
» Airworthiness Directives: BAE Systems (Operations) Limited Airplanes
» Airworthiness Directives: BAE Systems (Operations) Limited Airplanes
CFR: (1)
14 CFR 39.13