2010-11643. Airworthiness Directives; Bombardier-Rotax GmbH 912 F Series and 912 S Series Reciprocating Engines  

  • Start Preamble

    AGENCY:

    Federal Aviation Administration (FAA), DOT.

    ACTION:

    Notice of proposed rulemaking (NPRM).

    SUMMARY:

    We propose to adopt a new airworthiness directive (AD) for the products listed above. This proposed AD results from mandatory continuing airworthiness information (MCAI) issued by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as:

    Due to high fuel pressure, caused by exceeding pressure in front of the mechanical fuel pump (e.g. due to an electrical fuel pump), in limited cases a deviation in the fuel supply could occur. This can result in exceeding of the fuel pressure and might cause engine malfunction and/or massive fuel leakage.

    We are proposing this AD to prevent the pump from exceeding the fuel pressure, which could result in engine malfunction or a massive fuel leak. These conditions could cause loss of control of the airplane or a fire.

    DATES:

    We must receive comments on this proposed AD by July 1, 2010.

    ADDRESSES:

    You may send comments by any of the following methods:

    • Federal eRulemaking Portal: Go to http://www.regulations.gov and follow the instructions for sending your comments electronically.
    • Mail: Docket Management Facility, U.S. Department of Transportation, 1200 New Jersey Avenue, SE., West Building Ground Floor, Room W12-140, Washington, DC 20590-0001.
    • Hand Delivery: Deliver to Mail address above between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.
    • Fax: (202) 493-2251.

    Contact BRP-Rotax GmbH & Co. KG, Welser Strasse 32, A-4623 Gunskirchen, Austria, or go to: http://www.rotax-aircraft-engines.com/​, for the service information identified in this proposed AD.

    Examining the AD Docket

    You may examine the AD docket on the Internet at http://www.regulations.gov; or in person at the Docket Operations office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this proposed AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Operations office (telephone (800) 647-5527) is the same as the Mail address provided in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.

    Start Further Info

    FOR FURTHER INFORMATION CONTACT:

    Tara Chaidez, Aerospace Engineer, Engine Certification Office, FAA, Engine and Propeller Directorate, 12 New England Executive Park, Burlington, MA 01803; e-mail: tara.chaidez@faa.gov; telephone (781) 238-7773; fax (781) 238-7199.

    End Further Info End Preamble Start Supplemental Information

    SUPPLEMENTARY INFORMATION:

    Comments Invited

    We invite you to send any written relevant data, views, or arguments about Start Printed Page 27488this proposed AD. Send your comments to an address listed under the ADDRESSES section. Include “Docket No. FAA-2010-0499; Directorate Identifier 2010-NE-06-AD” at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this proposed AD. We will consider all comments received by the closing date and may amend this proposed AD based on those comments.

    We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact with FAA personnel concerning this proposed AD. Using the search function of the Web site, anyone can find and read the comments in any of our dockets, including, if provided, the name of the individual who sent the comment (or signed the comment on behalf of an association, business, labor union, etc.). You may review the DOT's complete Privacy Act Statement in the Federal Register published on April 11, 2000 (65 FR 19477-78).

    Discussion

    The European Aviation Safety Agency (EASA), which is the Technical Agent for the Member States of the European Community, has issued EASA Airworthiness Directive 2007-0060R1-E, dated April 20, 2007 (referred to after this as “the MCAI”), to correct an unsafe condition for the specified products. The MCAI states:

    Due to high fuel pressure, caused by exceeding pressure in front of the mechanical fuel pump (e.g. due to an electrical fuel pump), in limited cases a deviation in the fuel supply could occur. This can result in exceeding of the fuel pressure and might cause engine malfunction and/or massive fuel leakage.

    If the operator has shown compliance with BRP Rotax ASB-912-053, dated February 20, 2007, as mandated by EASA Airworthiness Directive 2007-0060-E, no further action is required.

    You may obtain further information by examining the MCAI in the AD docket.

    Relevant Service Information

    Rotax Aircraft Engines has issued Service Bulletin SB-912-053, dated April 13, 2007. The actions described in this service information are intended to correct the unsafe condition identified in the MCAI.

    FAA's Determination and Requirements of This Proposed AD

    This product has been approved by the aviation authority of Austria, and is approved for operation in the United States. Pursuant to our bilateral agreement with Austria, they have notified us of the unsafe condition described in the MCAI and service information referenced above. We are proposing this AD because we evaluated all information provided by EASA and determined the unsafe condition exists and is likely to exist or develop on other products of the same type design.

    Costs of Compliance

    Based on the service information, we estimate that this proposed AD would affect about 50 products of U.S. registry. We also estimate that it would take about 0.5 work-hour per product to comply with this proposed AD. The average labor rate is $85 per work-hour. Required parts would cost about $650 per product. Based on these figures, we estimate the cost of the proposed AD on U.S. operators to be $34,625.

    Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. “Subtitle VII: Aviation Programs,” describes in more detail the scope of the Agency's authority.

    We are issuing this rulemaking under the authority described in “Subtitle VII, Part A, Subpart III, Section 44701: General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

    Regulatory Findings

    We determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.

    For the reasons discussed above, I certify this proposed regulation:

    1. Is not a “significant regulatory action” under Executive Order 12866;

    2. Is not a “significant rule” under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and

    3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

    We prepared a regulatory evaluation of the estimated costs to comply with this proposed AD and placed it in the AD docket.

    Start List of Subjects

    List of Subjects in 14 CFR Part 39

    • Air transportation
    • Aircraft
    • Aviation safety
    • Safety
    End List of Subjects

    The Proposed Amendment

    Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:

    Start Part

    PART 39—AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Start Authority

    Authority: 49 U.S.C. 106(g), 40113, 44701.

    End Authority
    [Amended]

    2. The FAA amends § 39.13 by adding the following new AD:

    Bombardier-Rotax GmbH (Formerly Motorenfabrik): Docket No. FAA-2010-0499; Directorate Identifier 2010-NE-06-AD.

    Comments Due Date

    (a) We must receive comments by July 1, 2010.

    Affected Airworthiness Directives (ADs)

    (b) None.

    Applicability

    (c) This AD applies to Bombardier-Rotax 912 F series and 912 S series reciprocating engines with fuel pumps, part numbers (P/Ns) 892230, 892232, 892540 (standard version) or P/Ns 892235, 892236, 892545 (version including flexible fuel line), installed. These engines are installed on, but not limited to, Diamond (formerly HOAC) HK-36R Super Dimona, Aeromot AMT-200S Super Ximango; Diamond DA20-A1 Katana; Scheibe SF 25C; Iniziative Industriali Italiane S.p.A. Sky Arrow 650 TC, and 650 TCN airplanes.

    Reason

    (d) This AD results from mandatory continuing airworthiness information (MCAI) issued by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as:

    Due to high fuel pressure, caused by exceeding pressure in front of the mechanical fuel pump (e.g. due to an electrical fuel pump), in limited cases a deviation in the fuel supply could occur. This can result in exceeding of the fuel pressure and might Start Printed Page 27489cause engine malfunction and/or massive fuel leakage.

    We are issuing this AD to prevent the pump from exceeding the fuel pressure, which could result in engine malfunction or a massive fuel leak. These conditions could cause loss of control of the airplane or a fire.

    Actions and Compliance

    (e) Unless already done, do the following actions.

    (1) At the next maintenance, or within the next 25 hours of engine operation, whichever occurs first, after the effective date of this AD, remove affected fuel pumps, P/Ns 892230, 892232, 892235, 892236, 892540, or 892545.

    (2) After the effective date of this AD, do not install fuel pump, P/Ns 892230, 892232, 892235, 892236, 892540, or 892545, on any engine.

    FAA AD Differences

    (f) This AD differs from the MCAI and/or service information as follows: The MCAI requires replacing an affected fuel pump with fuel pump, P/N 892542 or 892546. This AD requires replacement of an affected fuel pump with a fuel pump eligible for installation on the airplane.

    Other FAA AD Provisions

    (g) Alternative Methods of Compliance (AMOCs): The Manager, Engine Certification Office, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19.

    Related Information

    (h) Refer to MCAI Airworthiness Directive 2007—0060R1—E, dated April 20, 2007, and Rotax Aircraft Engines Service Bulletin SB-912-053, dated April 13, 2007, for related information. Contact BRP-Rotax GmbH & Co. KG, Welser Strasse 32, A-4623 Gunskirchen, Austria, or go to: http://www.rotax-aircraft-engines.com/​, for a copy of this service information.

    (i) Contact Tara Chaidez, Aerospace Engineer, Engine Certification Office, FAA, Engine and Propeller Directorate, 12 New England Executive Park, Burlington, MA 01803; e-mail: tara.chaidez@faa.gov; telephone (781) 238-7773; fax (781) 238-7199, for more information about this AD.

    Start Signature

    Issued in Burlington, Massachusetts, on May 10, 2010.

    Peter A. White,

    Assistant Manager, Engine and Propeller Directorate, Aircraft Certification Service.

    End Signature End Part End Supplemental Information

    [FR Doc. 2010-11643 Filed 5-14-10; 8:45 am]

    BILLING CODE 4910-13-P

Document Information

Comments Received:
0 Comments
Published:
05/17/2010
Department:
Federal Aviation Administration
Entry Type:
Proposed Rule
Action:
Notice of proposed rulemaking (NPRM).
Document Number:
2010-11643
Dates:
We must receive comments on this proposed AD by July 1, 2010.
Pages:
27487-27489 (3 pages)
Docket Numbers:
Docket No. FAA-2010-0499, Directorate Identifier 2010-NE-06-AD
RINs:
2120-AA64: Airworthiness Directives
RIN Links:
https://www.federalregister.gov/regulations/2120-AA64/airworthiness-directives
Topics:
Air transportation, Aircraft, Aviation safety, Safety
PDF File:
2010-11643.pdf
CFR: (1)
14 CFR 39.13