2019-16608. Airworthiness Directives; Dassault Aviation Airplanes  

  • Start Preamble

    AGENCY:

    Federal Aviation Administration (FAA), DOT.

    ACTION:

    Notice of proposed rulemaking (NPRM).

    SUMMARY:

    The FAA proposes to adopt a new airworthiness directive (AD) for all Dassault Aviation Model MYSTERE FALCON 50, MYSTERE FALCON 900, and FALCON 900EX airplanes; and Model FALCON 2000 and FALCON 2000EX airplanes. This proposed AD was prompted by a report that the Dassault maintenance planning document (MPD) of the related Dassault aircraft maintenance manual (AMM) states that the “combined service/storage life” of the fire extinguisher percussion cartridges is longer than it should be, and could have a safety impact in case of fire. This proposed AD would require replacing the fire extinguisher percussion cartridges with serviceable parts. The FAA is proposing this AD to address the unsafe condition on these products.

    DATES:

    The FAA must receive comments on this proposed AD by September 27, 2019.

    ADDRESSES:

    You may send comments, using the procedures found in 14 CFR 11.43 and 11.45, by any of the following methods:

    • Federal eRulemaking Portal: Go to http://www.regulations.gov. Follow the instructions for submitting comments.
    • Fax: 202-493-2251.
    • Mail: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE, Washington, DC 20590.
    • Hand Delivery: Deliver to Mail address above between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.

    For service information identified in this NPRM, contact Dassault Falcon Jet Corporation, Teterboro Airport, P.O. Box 2000, South Hackensack, NJ 07606; telephone 201-440-6700; internet http://www.dassaultfalcon.com. You may view this service information at the FAA, Transport Standards Branch, 2200 South 216th St., Des Moines, WA. For information on the availability of this material at the FAA, call 206-231-3195.Start Printed Page 39992

    Examining the AD Docket

    You may examine the AD docket on the internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2019-0604; or in person at Docket Operations between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this NPRM, the regulatory evaluation, any comments received, and other information. The street address for Docket Operations is listed above. Comments will be available in the AD docket shortly after receipt.

    Start Further Info

    FOR FURTHER INFORMATION CONTACT:

    Tom Rodriguez, Aerospace Engineer, International Section, Transport Standards Branch, FAA, 2200 South 216th St., Des Moines, WA 98198; telephone and fax 206-231-3226.

    End Further Info End Preamble Start Supplemental Information

    SUPPLEMENTARY INFORMATION:

    Comments Invited

    The FAA invites you to send any written relevant data, views, or arguments about this proposal. Send your comments to an address listed under the ADDRESSES section. Include “Docket No. FAA-2019-0604; Product Identifier 2019-NM-072-AD” at the beginning of your comments. The FAA specifically invites comments on the overall regulatory, economic, environmental, and energy aspects of this NPRM. The FAA will consider all comments received by the closing date and may amend this NPRM because of those comments.

    The FAA will post all comments received, without change, to http://www.regulations.gov,, including any personal information you provide. The FAA will also post a report summarizing each substantive verbal contact received about this NPRM.

    Discussion

    The European Aviation Safety Agency (EASA), which is the Technical Agent for the Member States of the European Union, has issued EASA AD 2019-0084, dated April 17, 2019 (referred to after this as the Mandatory Continuing Airworthiness Information, or “the MCAI”), to correct an unsafe condition for all Dassault Aviation Model MYSTERE FALCON 50, MYSTERE FALCON 900, and FALCON 900EX airplanes; and Model FALCON 2000 and FALCON 2000EX airplanes. The MCAI states:

    It was identified that the Dassault Maintenance Planning Document (MPD) of the related Dassault Aircraft Maintenance Manual (AMM) for affected aeroplanes mentions that “combined service/storage life” of the affected parts is 12 years, whereas it should be 10 years. The related technical investigation confirmed that this could have a safety impact in case of fire. It is expected that Dassault will update the MPD with the correct value.

    This condition, if not corrected, could prevent extinguishing a fire, possibly resulting in damage to the aeroplane and injury to the occupants.

    For the reasons described above, this [EASA] AD requires replacement of affected parts with serviceable parts.

    You may examine the MCAI in the AD docket on the internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2019-0604.

    FAA's Determination

    This product has been approved by the aviation authority of another country, and is approved for operation in the United States. Pursuant to a bilateral agreement with the State of Design Authority, the FAA has been notified of the unsafe condition described in the MCAI and service information referenced above. The FAA is proposing this AD because the agency evaluated all the relevant information and determined the unsafe condition described previously is likely to exist or develop on other products of the same type design.

    Proposed Requirements of This NPRM

    This proposed AD would require replacing the fire extinguisher percussion cartridges with serviceable parts.

    Costs of Compliance

    The FAA estimates that this proposed AD affects 1,013 airplanes of U.S. registry. The FAA estimates the following costs to comply with this proposed AD:

    Estimated Costs for Required Actions

    Labor costParts costCost per productCost on U.S. operators
    6 work-hours × $85 per hour = $510$1,145$1,655$1,676,515

    Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs, describes in more detail the scope of the Agency's authority.

    The FAA is issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701: “General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

    This proposed AD is issued in accordance with authority delegated by the Executive Director, Aircraft Certification Service, as authorized by FAA Order 8000.51C. In accordance with that order, issuance of ADs is normally a function of the Compliance and Airworthiness Division, but during this transition period, the Executive Director has delegated the authority to issue ADs applicable to transport category airplanes and associated appliances to the Director of the System Oversight Division.

    Regulatory Findings

    The FAA determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.

    For the reasons discussed above, I certify this proposed regulation:

    1. Is not a “significant regulatory action” under Executive Order 12866;

    2. Will not affect intrastate aviation in Alaska; and

    3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

    Start List of Subjects Start Printed Page 39993

    List of Subjects in 14 CFR Part 39

    • Air transportation
    • Aircraft
    • Aviation safety
    • Incorporation by reference
    • Safety
    End List of Subjects

    The Proposed Amendment

    Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:

    Start Part

    PART 39—AIRWORTHINESS DIRECTIVES

    End Part Start Amendment Part

    1. The authority citation for part 39 continues to read as follows:

    End Amendment Part Start Authority

    Authority: 49 U.S.C. 106(g), 40113, 44701.

    End Authority
    [Amended]
    Start Amendment Part

    2. The FAA amends § 39.13 by adding the following new airworthiness directive (AD):

    End Amendment Part

    Dassault Aviation: Docket No. FAA-2019-0604; Product Identifier 2019-NM-072-AD.

    (a) Comments Due Date

    The FAA must receive comments by September 27, 2019.

    (b) Affected ADs

    None.

    (c) Applicability

    This AD applies to all Dassault Aviation Model MYSTERE FALCON 50, MYSTERE FALCON 900, and FALCON 900EX airplanes; and Model FALCON 2000 and FALCON 2000EX airplanes; certificated in any category.

    (d) Subject

    Air Transport Association (ATA) of America Code 26, Fire protection.

    (e) Reason

    This AD was prompted by a report that the Dassault maintenance planning document (MPD) of the related Dassault aircraft maintenance manual (AMM) mentions that the “combined service/storage life” of the fire extinguisher percussion cartridges is 12 years, whereas it should be 10 years, and could have a safety impact in case of fire. The FAA is issuing this AD to address the total life limit of the fire extinguisher percussion cartridges, which if not corrected, could prevent extinguishing a fire and possibly result in damage to the airplane and injury to occupants.

    (f) Compliance

    Comply with this AD within the compliance times specified, unless already done.

    (g) Definitions

    For the purpose of this AD, the definitions specified in paragraphs (g)(1), (g)(2), (g)(3), and (g)(4) apply to this AD.

    (1) An affected part is a fire extinguisher percussion cartridge having part number (P/N) 862700-00 or P/N 862710-00.

    (2) Total life is time since the manufacturing date, which includes both the time installed on an airplane and time in storage.

    (3) A serviceable part is an affected part that has not exceeded 10 years of total life, or a fire extinguisher percussion cartridge that is not an affected part.

    (4) Group 1 airplanes are those that have an affected part installed. Group 2 airplanes are those that do not have an affected part installed.

    (h) Total Life Limit Implementation

    For Group 1 airplanes, except as specified in paragraph (j) of this AD: Before a fire extinguisher percussion cartridge exceeds 10 years of total life, remove the affected part and replace it with a serviceable part in accordance with the procedures specified in paragraph (l)(2) of this AD.

    (i) Guidance for Replacement Required by Paragraph (h) of This AD

    Guidance for the replacement specified in paragraph (h) of this AD can be found in the applicable Dassault AMM task as specified in figure 1 to paragraph (i) of this AD.

    Start Printed Page 39994

    (j) Grace Period for Initial Replacement

    For Group 1 airplanes: For a fire extinguisher percussion cartridge that, on the effective date of this AD, has a total life of 9 years 6 months or more, the replacement required by paragraph (h) of this AD can be deferred up to 6 months after the effective date of this AD.

    (k) Parts Installation Limitations

    For Group 1 and Group 2 airplanes: As of the effective date of this AD, no person may install, on any airplane, a fire extinguisher percussion cartridge, unless the part is a serviceable part as specified in this AD, and that, following installation, the affected part is replaced as required by paragraph (h) of this AD.

    (l) Other FAA AD Provisions

    The following provisions also apply to this AD:

    (1) Alternative Methods of Compliance (AMOCs): The Manager, International Section, Transport Standards Branch, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the International Section, send it to the attention of the person identified in paragraph (m)(2) of this AD. Information may be emailed to: 9-ANM-116-AMOC-REQUESTS@faa.gov. Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/certificate holding district office.

    (2) Contacting the Manufacturer: For any requirement in this AD to obtain corrective actions from a manufacturer, the action must be accomplished using a method approved by the Manager, International Section, Transport Standards Branch, FAA; or the European Aviation Safety Agency (EASA); or Dassault Aviation's EASA Design Organization Approval (DOA). If approved by the DOA, the approval must include the DOA-authorized signature.

    (m) Related Information

    (1) Refer to Mandatory Continuing Airworthiness Information (MCAI) EASA AD 2019-0084, dated April 17, 2019, for related information. This MCAI may be found in the AD docket on the internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2019-0604.

    (2) For more information about this AD, contact Tom Rodriguez, Aerospace Engineer, International Section, Transport Standards Branch, FAA, 2200 South 216th St., Des Moines, WA 98198; telephone and fax 206-231-3226.

    (3) For service information identified in this AD, contact Dassault Falcon Jet Corporation, Teterboro Airport, P.O. Box 2000, South Hackensack, NJ 07606; telephone 201-440-6700; internet http://www.dassaultfalcon.com. You may view this service information at the FAA, Transport Standards Branch, 2200 South 216th St., Des Moines, WA. For information on the availability of this material at the FAA, call 206-231-3195.

    Start Signature

    Issued in Des Moines, Washington, on July 26, 2019.

    Dionne Palermo,

    Acting Director, System Oversight Division, Aircraft Certification Service.

    End Signature End Supplemental Information

    [FR Doc. 2019-16608 Filed 8-12-19; 8:45 am]

    BILLING CODE 4910-13-P

Document Information

Published:
08/13/2019
Department:
Federal Aviation Administration
Entry Type:
Proposed Rule
Action:
Notice of proposed rulemaking (NPRM).
Document Number:
2019-16608
Dates:
The FAA must receive comments on this proposed AD by September 27, 2019.
Pages:
39991-39994 (4 pages)
Docket Numbers:
Docket No. FAA-2019-0604, Product Identifier 2019-NM-072-AD
RINs:
2120-AA64: Airworthiness Directives
RIN Links:
https://www.federalregister.gov/regulations/2120-AA64/airworthiness-directives
Topics:
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety
PDF File:
2019-16608.Pdf
CFR: (1)
14 CFR 39.13