-
Start Preamble
AGENCY:
Federal Aviation Administration (FAA), DOT.
ACTION:
Final rule.
SUMMARY:
The FAA is adopting a new airworthiness directive (AD) for all Airbus Helicopters Model EC120B helicopters. This AD was prompted by a report of geometrical non-conformities in the tail rotor blade (TRB) root section discovered during an accident investigation of a Model EC130B helicopter. Due to the similarity of design and production requirements, certain TRBs for the Model EC120B helicopters were inspected and Start Printed Page 7706 geometrical non-conformities were also found. This AD requires an inspection (dimensional check) to verify conformity, and replacement of certain TRBs if necessary, as specified in a European Union Aviation Safety Agency (EASA) AD, which is incorporated by reference. The FAA is issuing this AD to address the unsafe condition on these products.
DATES:
This AD is effective March 17, 2022.
The Director of the Federal Register approved the incorporation by reference of a certain publication listed in this AD as of March 17, 2022.
ADDRESSES:
For EASA material incorporated by reference (IBR) in this AD, contact EASA, Konrad-Adenauer-Ufer 3, 50668 Cologne, Germany; phone: +49 221 8999 000; email: ADs@easa.europa.eu; internet: www.easa.europa.eu. You may find the EASA material on the EASA website at https://ad.easa.europa.eu. You may view this material at the FAA, Office of the Regional Counsel, Southwest Region, 10101 Hillwood Pkwy., Room 6N-321, Fort Worth, TX 76177. For information on the availability of this material at the FAA, call (817) 222-5110. It is also available in the AD docket at https://www.regulations.gov by searching for and locating Docket No. FAA-2021-0886.
Examining the AD Docket
You may examine the AD docket at https://www.regulations.gov by searching for and locating Docket No. FAA-2021-0886; or in person at Docket Operations between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this final rule, the EASA AD, any comments received, and other information. The address for Docket Operations is U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE, Washington, DC 20590.
Start Further InfoFOR FURTHER INFORMATION CONTACT:
Andrea Jimenez, Aerospace Engineer, COS Program Management Section, Operational Safety Branch, Compliance & Airworthiness Division, FAA, 1600 Stewart Ave., Suite 410, Westbury, NY 11590; phone: (516) 228-7330; email: andrea.jimenez@faa.gov.
End Further Info End Preamble Start Supplemental InformationSUPPLEMENTARY INFORMATION:
Background
EASA, which is the Technical Agent for the Member States of the European Union, has issued EASA AD 2021-0079, dated March 17, 2021 (EASA AD 2021-0079), to correct an unsafe condition for all Airbus Helicopters Model EC120B helicopters.
The FAA issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 by adding an AD that would apply to all Airbus Helicopters Model EC120B helicopters. The NPRM published in the Federal Register on October 28, 2021 (86 FR 59653). The NPRM was prompted by a report of geometrical non-conformities in the TRB root section discovered during an accident investigation of a Model EC130B helicopter. Due to the similarity of design and production requirements, certain TRBs for the Model EC120B helicopters were inspected and geometrical non-conformities were also found. The NPRM proposed to require an inspection (dimensional check) to verify conformity, and replacement of certain TRBs if necessary, as specified in EASA AD 2021-0079.
The FAA is issuing this AD to detect and correct geometrical non conformities of the TRB root section. The unsafe condition, if not addressed, could result in crack initiation and TRB failure, and possibly result in loss of control of the helicopter. See EASA AD 2021-0079 for additional background information.
Discussion of Final Airworthiness Directive
Comments
The FAA received no comments on the NPRM or on the determination of the costs.
Conclusion
These helicopters have been approved by EASA and are approved for operation in the United States. Pursuant to the FAA's bilateral agreement with the European Union, EASA has notified the FAA about the unsafe condition described in its AD. The FAA reviewed the relevant data and determined that air safety requires adopting this AD as proposed. Accordingly, the FAA is issuing this AD to address the unsafe condition on these helicopters. Except for minor editorial changes, this AD is adopted as proposed in the NPRM.
Related Service Information Under 1 CFR Part 51
EASA AD 2021-0079 requires an inspection (dimensional check) to verify TRB conformity, and replacement of certain TRBs if necessary. EASA AD 2021-0079 also prohibits rework, repair, or modification of affected parts in the critical section (affected area of the TRB assembly root).
This material is reasonably available because the interested parties have access to it through their normal course of business or by the means identified in the ADDRESSES section.
Costs of Compliance
The FAA estimates that this AD affects 89 helicopters of U.S. Registry. Labor rates are estimated at $85 per work-hour. Based on these numbers, the FAA estimates the following costs to comply with this AD.
Estimated Costs
Action Labor cost Parts cost Cost per product Cost on U.S. operators Inspection 4 work-hours × $85 per hour = $340 $0 $340 $30,260 The FAA estimates the following costs to do any necessary replacements that would be required based on the results of the required inspection. The agency has no way of determining the number of aircraft that might need these replacements:
Start Printed Page 7707On-Condition Costs
Action Labor cost Parts cost Cost per product Blade Replacement 10 work-hours × $85 per hour = $850 $4,000 $4,850 The FAA has included all known costs in its cost estimate. According to the manufacturer, however, some of the costs of this AD may be covered under warranty, thereby reducing the cost impact on affected operators.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs, describes in more detail the scope of the Agency's authority.
The FAA is issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701: General requirements. Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
This AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that this AD:
(1) Is not a “significant regulatory action” under Executive Order 12866,
(2) Will not affect intrastate aviation in Alaska, and
(3) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
Start List of SubjectsList of Subjects in 14 CFR Part 39
- Air transportation
- Aircraft
- Aviation safety
- Incorporation by reference
- Safety
The Amendment
Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:
Start PartPART 39—AIRWORTHINESS DIRECTIVES
End Part Start Amendment Part1. The authority citation for part 39 continues to read as follows:
End Amendment Part[Amended]2. The FAA amends § 39.13 by adding the following new airworthiness directive:
End Amendment Part2022-02-06 Airbus Helicopters: Amendment 39-21903; Docket No. FAA-2021-0886; Project Identifier MCAI-2021-00341-R.
(a) Effective Date
This airworthiness directive (AD) is effective March 17, 2022.
(b) Affected ADs
None.
(c) Applicability
This AD applies to all Airbus Helicopters Model EC120B helicopters, certificated in any category.
(d) Subject
Joint Aircraft Service Component (JASC) Code: 6410, Tail Rotor Blades.
(e) Unsafe Condition
This AD was prompted by a report of geometrical non-conformities in the tail rotor blade (TRB) root section discovered during an accident investigation of a Model EC130B helicopter. Due to the similarity of design and production requirements, certain TRBs for the Model EC120B helicopters were inspected and geometrical non-conformities were also found. The FAA is issuing this AD to detect and correct geometrical non-conformities of the TRB root section. The unsafe condition, if not addressed, could result in crack initiation and TRB failure, and possibly result in loss of control of the helicopter.
(f) Compliance
Comply with this AD within the compliance times specified, unless already done.
(g) Requirements
Except as specified in paragraph (h) of this AD: Comply with all required actions and compliance times specified in, and in accordance with, European Union Aviation Safety Agency (EASA) AD 2021-0079, dated March 17, 2021 (EASA AD 2021-0079).
(h) Exceptions to EASA AD 2021-0079
(1) Where EASA AD 2021-0079 requires compliance in terms of flight hours, this AD requires using hours time-in-service.
(2) Where EASA AD 2021-0079 refers to its effective date, this AD requires using the effective date of this AD.
(3) Where the service information referenced in EASA AD 2021-0079 specifies discarding a part, this AD requires removing that part from service.
(4) This AD does not mandate compliance with the “Remarks” section of EASA AD 2021-0079.
(5) Where the service information referenced in EASA AD 2021-0079 specifies to measure using the Smartphone application, the PowerPoint method, or “Contacting customer support with a specific procedure,” this AD requires determining the specified measurements but those methods of measurement are not required by this AD.
(i) No Reporting Requirement
Although the service information referenced in EASA AD 2021-0079 specifies to submit certain information to the manufacturer, this AD does not include that requirement.
(j) Special Flight Permit
Special flight permits may be issued in accordance with 14 CFR 21.197 and 21.199 to operate the helicopter to a location where the actions of this AD can be performed, provided no passengers are onboard.
(k) Alternative Methods of Compliance (AMOCs)
(1) The Manager, International Validation Branch, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the manager of the International Validation Branch, send it to the attention of the person identified in paragraph (l) of this AD. Information may be emailed to: 9-AVS-AIR-730-AMOC@faa.gov.
(2) Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/certificate holding district office.
(l) Related Information
For more information about this AD, contact Andrea Jimenez, Aerospace Engineer, COS Program Management Section, Operational Safety Branch, Compliance & Airworthiness Division, FAA, 1600 Stewart Ave., Suite 410, Westbury, NY 11590; phone: (516) 228-7330; email: andrea.jimenez@faa.gov.
(m) Material Incorporated by Reference
(1) The Director of the Federal Register approved the incorporation by reference of the service information listed in this paragraph under 5 U.S.C. 552(a) and 1 CFR part 51.
(2) You must use this service information as applicable to do the actions required by this AD, unless this AD specifies otherwise.
(i) European Union Aviation Safety Agency (EASA) AD 2021-0079, dated March 17, 2021.
(ii) [Reserved]
(3) For EASA AD 2021-0079, contact EASA, Konrad-Adenauer-Ufer 3, 50668 Cologne, Germany; phone: +49 221 8999 000; email: ADs@easa.europa.eu; internet: www.easa.europa.eu. You may find the EASA material on the EASA website at https://ad.easa.europa.eu.
(4) You may view this service information at the FAA, Office of the Regional Counsel, Southwest Region, 10101 Hillwood Pkwy., Room 6N-321, Fort Worth, TX 76177. For information on the availability of this material at the FAA, call (817) 222-5110. This material may be found in the AD docket Start Printed Page 7708 at https://www.regulations.gov by searching for and locating Docket No. FAA-2021-0886.
(5) You may view this material that is incorporated by reference at the National Archives and Records Administration (NARA). For information on the availability of this material at NARA, email fr.inspection@nara.gov, or go to: https://www.archives.gov/federal-register/cfr/ibr-locations.html.
Start SignatureIssued on January 7, 2022.
Lance T. Gant,
Director, Compliance & Airworthiness Division, Aircraft Certification Service.
[FR Doc. 2022-02748 Filed 2-9-22; 8:45 am]
BILLING CODE 4910-13-P
Document Information
- Effective Date:
- 3/17/2022
- Published:
- 02/10/2022
- Department:
- Federal Aviation Administration
- Entry Type:
- Rule
- Action:
- Final rule.
- Document Number:
- 2022-02748
- Dates:
- This AD is effective March 17, 2022.
- Pages:
- 7705-7708 (4 pages)
- Docket Numbers:
- Docket No. FAA-2021-0886, Project Identifier MCAI-2021-00341-R, Amendment 39-21903, AD 2022-02-06
- RINs:
- 2120-AA64: Airworthiness Directives
- RIN Links:
- https://www.federalregister.gov/regulations/2120-AA64/airworthiness-directives
- Topics:
- Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety
- PDF File:
- 2022-02748.pdf
- Supporting Documents:
- » Airworthiness Directives: Airbus Helicopters
- » Supporting AD Document
- » Airworthiness Directives: Airbus Helicopters
- CFR: (1)
- 14 CFR 39.13